Daily Archives: October 4, 2014

What Counts? Product A or Product B

Blower Door Testing & Weather Resistant Barrier

Tyvek TopThe practice of covering sheathing with asphalt impregnated papers has given way to the use of synthetic fabrics, known as house wrap; or spray on coatings. There are factory applied coatings on some brands of sheathing and some types of coatings are field applied. Along with the discussions of fiberglass / cellulose in the insulating of homes, there has been plenty of discussion about the merits of one form or another of WRBs.

As with any step in the building process, I believe it is less about the product and more about the people. Products that are hard to install will be less successful then others. Installers that are not properly trained; work that is not verified in some manner can defeat the proper performance of the best products.

WRBWhat does the WRB do for a home. First it provides a drainage plane behind the siding to divert rain and other weather related moisture from wetting the sheathing. Second, when all manufacturers install instructions are followed it can act as an air barrier, reducing infiltration. For the house wrap type fabrics, this means properly lapped, using capped fasteners, and then taped. Finding house wrap installed according to manufacturer’s install directions is rare.

When all three of these directions are not followed, not only are the potential qualities of an air barrier not present, the potential for water to run behind an uncapped fastener, or an incorrectly lapped joint, which is also untaped. Repeated wetting of the sheathing over time, will eventually result in rot and the accompanying problems.

Country HollowA local Wichita Home Builder, G.J. Gardner has just finished two homes based on the same floor plan. These homes went through the independent verification process involved in obtaining a HERS Rating. These homes utilized the same sub-contractors and types of insulation. The only difference in construction was the use of a job site applied spray on WRB, in place of a house wrap type fabric.

One part of this verification process is a Blower Door Test. This test simulates the effects of a 20 mph wind on all sides of the home at the same time. Blower Door testing has been completed on homes since the late 1970’s. Energy efficiency programs and building codes have consistently recognized the value of a Blower Door test on each home.

BlowerDoorThe value of doing a Blower Door test on each home is primarily to check the work of all subs has not compromised the Builder’s plan for an energy efficient home. Many existing homes, have a test rate of 7 – 12 or higher rates of air exchange during the test. The 2012 code requirement is 3 on this scale, and lower is better.

The use of 4×8 sheet goods for sheathing and other simple, and inexpensive techniques have brought the infiltration rates down. This reduces the cases of cold drafty homes, and significantly lowering the energy use of a home.

The Blower Door test can verify the quality of work involved with installing the WRB, specifically the degree of sealing of the outside of the sheathing. In the case of the two homes involved in this comparison, there was a change of 20% in the measured infiltration rates of the two homes.

In completing the Blower Door tests, we used the ANSI / RESNET published standard of a Multi-point test. These results were entered into a software package provided by the maker of the blower door, The Energy Conservatory, Below is a comparison screen between the two Blower Door Tests.

Tectite 2 Bldg Comp Data

I would like to thank Wade Wilkinson, with GJ Gardner of Wichita; his subcontractors and their technicians for building quality energy efficient homes. I enjoy being able to verify the quality of their work.

If you would like to see this home, it is currently in the Fall 2014, WABA Parade of Homes.  It is located in the Country Hollow Development.  Between Kellogg and Harry on 127th and East to Glen Hills Court, on the corner.  Find out also about the HERS Index earned by this home. It will save you operating costs on your Energy Bills.